photo-electric logo  Autosleepers Nuevo

The Relentless Advance of Technology c/w filthy weather

15/06/2019

UPDATE
I managed to flatten my leisure battery!
Bummer.
I left the van parked up with everything switched off but I forgot to switch of the fridge and it was on battery power.
Now the fridge is switched off when the engine is not running BUT I left the fridge door open and the fridge light was on.
It's only 2 watts but that corresponds to 4 ampere hours (AH) per day. It was March so the wee solar panel conributed very little.  A month results in 112 AH - so flat battery.
I should have used the isolator switch.  Anyway I charged it up again with the CTEK charger and it;s working OK but capacity is almost certainly reduced - but to what?
After charging the wee solar panel has kept the voltage of both batteries around 12.8V

Back in 2014 when I first did my calculations I estimated that phones, tablets, and computers would take an average of 14AH a day while were out and about at festivals and on holidays.

Things have changed in five years.  The technology items have got more power hungry and we find that we use the van a lot to visit folk so we spend a lot of time sitting in it. So we use more power demanding technolgy more often - a classic double whammy.

Here is what he have been doing over the last (incredibly wet) week in the van. (most charged from Buck/Boost converters so capacities normalised to 12V)

Device Battery % use per Day AH used per day
Lap top 4AH 75% 3
Ipad 3.6AH 50% 1.8
Smart Phone 1.2H 100% 1.2
iphone 0.6AH 15% 0.09
      =======
      6.09
      ======

Thats about 42AH per week!!   In 2014 I estimated 14.1AH!!!!  Add in the 13AH for the fridge re-igniter and 15AH for the lights and we are using around 72AH per week.

If you compare my various estimates you may see that they vary from page to page.  Not a lot. This is simply because as time goes on I can estimate better.

Now this has been an unusual week and the battery has survived because the week has ben punctuated with some travelling and a couple of times I ran the engine  and the wee solar panel has helped a little.

But more power is needed for this damned techology.  I don't need 72AH per week. The leisure battery can still supply a fair amount of power before it reaches 50% charge and the last weeks consumption is abnormally high. 

If I replace the 10W panel with a 40W panel (it still fits inside under the roof window) I can get 4 times what I calculated  last time -about 8AH per day, probably 12AH per day in the summer months.  That would cover everything we use.

A non standard approach

The usual method of using a panel is to attach it to the roof then use a charge controller to regulate the charge. Reading on the forums, the biggest hassle seems to be with charge controllers and the fitting of the panels.  So I decided to fit a 40W panel INSIDE the van under the roof window and not use a self designed and built controller.

After a few days of glorious sunshine without the controller , the batteries were up to 15.6V.  This is too high, so obviously a controller is needed. 

Here it is

Solar panele controller

The battery voltage reaches around 14V and the relay operates which switches the solar panel OUT.  The voltage drops to around 13.2V and the realy drops out (minimising drain on the battery) and the solar panel switches IN.  The LED is simply to tell if its working or not.

Update - After  a weekend at a folk festival with overcast weather every day, the leisure battery showed around 13.5V every night and around 12.7V every morning. This was charging two phones and ipad, a laptop, operating the lights (including the awning light for around 3 - 4 hours).
The jobs a good'un 

The panel supplies BOTH the leisure battery and the vehicle battery. They are separated by a couple of diodes so they can both be charged by the solar panel but cannot discharge into each other. This means that the lowest voltage is charged first then they charge together until the leisure battery reaches 14V.  So the panel is looking after them both.

I think the Nuevo habitation electrics are now finished.
We have had it now for 5 years and covered 80,000 miles, spending hundreds of nights in the van.  We have used a hook up once the only time we were on a campsite.  The rest of the time has been wild camping or a folk festivals with few amenities. 

Update.  A few days ago the company I bought the van from phoned to ask if I'd like to trade it in.  I considered the offer for a millisecond before saying NO.  I have not seen ANY van which is more suited to our lifestyle.

 


 Valid CSS Valid XHTML